Page 1 of 1

check engine 4age blue top (Code 6)

Posted: Wed Jan 06, 2016 2:59 pm
by hjmoncada
i friends.

I have a problem with the check engine
checking engine is always on
but low rpm 500 is off
but if I go up to over 4500 rpm shuting off automatically
but when he returns to between 500 and 4500 rpm check the engine on again

that could be the problem?

Re: check engine 4age blue top

Posted: Thu Jan 07, 2016 12:42 pm
by jondee86
Hi and welcome to club4AG :)

Have you tried to see if there are any fault codes stored in the ECU ?
To do that you have to short the two pins of the diagnostic plug with
a piece of wire, turn the ignition on, and read how many times the
CEL flashes.

Cheers... jondee86

Re: check engine 4age blue top

Posted: Thu Jan 07, 2016 1:33 pm
by hachipirate
Welcome to the club.

Like jondee said, have you gone through basic diagnostic procedure? Is it stock? What modifications?

Re: check engine 4age blue top

Posted: Sat Jan 09, 2016 5:03 pm
by hjmoncada
I made the bridge with a cable.
engine checking flashes 6 times and turns off.
delete the codes stored in the ECU and bridge again
flashes 6 times and this approximately three seconds off

but always in less than 500 RPM engine checking off
and when I step 4500 RPM turns off
I mean between 500 -4500 is always on the check engine
I will make a video link and will share them

sorry my english still in learning

Re: check engine 4age blue top

Posted: Sat Jan 09, 2016 5:55 pm
by jondee86
For an AE86 error code 6 is:

Code 6 RPM signal.
No Ne, G signal (engine revolution sensor) signal to ECU within
several seconds after engine is cranked. No Ne, G signal (engine revolution sensor)
signal to ECU within several seconds after engine reaches 1,000rpm.

Places to look:
Distributor circuit.
Distributor.
Igniter.
Starter signal circuit.
ECU.

I'd start by checking all the wiring around your distributor and igniter. Look
for broken or frayed wires, damaged plugs, shorts, burned wires. In particular
look at the wires just where they connect to the distributor which is where they
move around the most.

Cheers... jondee86

PS: You only need to post the question one time and then wait for an answer ;)

Re: check engine 4age blue top (Code 6)

Posted: Sun Sep 24, 2017 5:25 pm
by hjmoncada
some people here have a full manual repair for this car in pdf not have this part

Re: check engine 4age blue top (Code 6)

Posted: Sun Sep 24, 2017 6:40 pm
by jondee86
You can download it here... http://files.aeu86.org/manuals/4A-GEManual.pdf (92Mb)

Also the AE86 body manual... http://files.aeu86.org/manuals/AE86Manual.pdf (100Mb)

Cheers... jondee86

Re: check engine 4age blue top (Code 6)

Posted: Sat Oct 13, 2018 9:35 am
by hjmoncada
in this manuals page to check code 6 dosent exsit

Re: check engine 4age blue top (Code 6)

Posted: Sat Oct 13, 2018 3:56 pm
by jondee86
It is Page 85 in the download manusl... same information as this...

Image

Cheers... jondee86

Re: check engine 4age blue top (Code 6)

Posted: Sat Dec 22, 2018 10:31 am
by hjmoncada
but the manuals dont have page about how repair ditributor

Re: check engine 4age blue top (Code 6)

Posted: Sun Dec 23, 2018 4:16 pm
by jondee86
From the club4AG FAQ....

4AGE 16V - Distributor Rebuild - DIY by Matrix Garage

Cheers... jondee86